AUTONET TV

A Stitch in Time at Arizona Auto and Radiator Repair

You probably have heard that expression, "A stitch in time saves nine." In other words, if you fix an issue at its early stages, it will prevent a much more difficult problem later. That's certainly the case with your vehicle, and here's a true story to demonstrate it.

A driver noticed his vehicle was due for an oil change, so he took it in to his service facility early in the morning so he could wait while the work was performed. The technician routinely checks the battery on vehicles just before extreme weather is approaching (cold or hot), so with winter coming up, he hooked up the load tester (it measures voltage while a load is put on the battery). It showed the battery wasn't holding a charge well.

The technician checked the manufacturing date on the battery, too (most batteries have a date stamped in code somewhere on them). The date showed it was five years old. While batteries can last more than five years, many technicians say you should expect to get anywhere from three to six years out of them, depending on what they go through.

So, this battery was getting a little long in the tooth, and it wasn't holding a charge particularly well. But how much current was it being sent by the vehicle's alternator? If it wasn't getting enough, that might be a factor. A test of the charging system showed the alternator was putting out the correct amount of power. The technician recommended replacing the battery, and the driver agreed.

That was the stitch in time. Had the technician not checked the battery, that driver likely would have been stranded the next time he tried to start his vehicle on a very cold day. What originally was supposed to be just an oil change led to a technician's sharp diagnosis and a little preventative maintenance for one fortunate driver. Sometimes timing is everything.

Arizona Auto and Radiator Repair
1255 E FRY BLVD
Sierra Vista, AZ 85635
520-459-2216
http://www.azautorepair.net

Things Aren't Always What They Seem

If you drive, you know at some point, something's going to go wrong with your vehicle.  And sometimes, it's pretty easy to figure out what's wrong, like a flat tire.  But sometimes your vehicle's symptoms can be really puzzling.

One driver in AZ was heading to work on a hot July day and noticed when he pressed the accelerator, sometimes it wouldn't do anything. He also noticed his cruise control wouldn't work and his traction control light was constantly on, very unusual.

He was trying to figure it out, but none of it made any sense.  His cruise control had always worked perfectly, his traction light never had gone on before and there was never any issue pressing on the accelerator.

It was time to take his car in for a professional diagnosis, and boy, was he surprised that it was a freak accident he'd had the previous WINTER that was the root of his problems.  You see, in January, his car had slipped on ice when he was in reverse and had gently tapped a tree.  That caused a tiny crack in his rear stoplight. 

That crack had gone unnoticed until that July day.  Turns out a summer rain allowed water to seep into the taillight casing, so this time when he drove to work, there was enough moisture inside it to cause his stop light to stick on.

When the stop light is on, the car's computer is programmed to act as if the driver is pressing the brakes. It also disables the cruise, accelerator and cruise control when the brakes are on, producing all of the symptoms.  Replacing the stop lamp switch fixed everything.

So, while some things that go wrong with your vehicle are pretty obvious, many seemingly defy all logic. That's when a trained technician can scope things out, replace the right part and get you going again.

Let Arizona Auto and Radiator Repair Help You Keep Your Vehicle Another Couple of Years

Sierra Vista area residents may remember when the U.S. government's “Cash for Clunkers” program made a splash on the news scene. People were offered incentives to trade in old vehicles for new, in the interest of better and improved air quality from reduced emissions.

But a lot of Sierra Vista drivers want to hang onto their old clunkers. They're dependable and they're paid for. Owners would love to see the odometers on those vehicles turn past 200,000 miles (320,000 km), as long as the repair bills don't get too expensive.

There are a lot of vehicles on AZ roads that have run past the 200,000 mile (320,000 km) odometer reading. Is there something that their owners are doing that keeps these vehicles on the road? Or did they just win the “lemon lottery,” and luck out by getting a particularly good vehicle? Not surprisingly, most of these owners have something in common. They never skip an oil change. Can keeping a vehicle on the road for 200,000 miles (320,000 km) really be that easy for Sierra Vista drivers?

Actually, it makes sense. Oil is the lifeblood of a vehicle. Clean oil ensures that the engine will run efficiently and staves off the build-up of sludge that can eventually damage engine parts. Oil changes remove dirty oil and replace dirty oil filters, keeping an engine clean and running smoothly, just like eating right keeps our hearts healthy by preventing build-up in our arteries.

But there's another reason why not skipping an oil change can result in a longer life for your car. When you bring your car in to Arizona Auto and Radiator Repair for an oil change, all of the fluid levels are checked and topped off. If these fluids are depleted, dirty or low, they can damage the engine.

If a fluid is significantly low, it usually indicates a leak somewhere, leading to an inspection of relevant parts. This inspection and the replacement of the worn part can prevent repair bills and maintain the health of the engine.

At an oil change, your technician at Arizona Auto and Radiator Repair will also do a quick check for worn belts or hoses, uneven tread wear, leaking shock absorbers and other signs of wear and tear. This advance notice allows the owner to replace parts before they break down and possibly damage your vehicle.

The oil change is also a good time to review any other service that the vehicle might need. Many car owners rely on their pros at Arizona Auto and Radiator Repair for good auto advice on check-ups and follow-up vehicle care that will keep older cars running well.

Parts wear out on older vehicles. There's no avoiding it. As the odometer chugs upward toward 200,000 miles (320,000 km), the vehicle will need several batteries, a couple of alternators and water pumps, a new set of shocks and possibly some brake rotors. But these items—all together—add up to far less than the cost of a new vehicle.

Good vehicle care and preventive maintenance are the hallmark of Sierra Vista drivers who have kept their vehicles on the road and running past the age when most of us have given up and headed back to a car lot. We can learn from their wisdom.

So treat your car right: Take good care of it and don't skip the check-ups at Arizona Auto and Radiator Repair in Sierra Vista. 

Arizona Auto and Radiator Repair
1255 E FRY BLVD
Sierra Vista, AZ 85635
520-459-2216
http://www.azautorepair.net

PCV Valve: What Is It?

Most Sierra Vista drivers know something about preventive maintenance on a vehicle. We know we should routinely replace the oil and wiper blades and other fluids. But have you heard of a PCV valve ? This little car part needs to be replaced regularly or it can cause some serious problems in your vehicle engine.

PCV stands for Positive Crankcase Ventilation. The crankcase holds your motor oil and is located at the bottom of your engine.

When fuel is burned in your engine, it produces waste gases that are mostly vented out through your exhaust system. But some of these gases push their way past the pistons and into the crankcase. There, these gases can mix with motor oil to produce oil sludge, which can damage vehicle engine parts through corrosion and by clogging engine passages. Sierra Vista vehicle owners should be advised that if the engine is running at high speeds, these gases can also cause pressure inside the crankcase to build up. This pressure, in turn, can blow gaskets and damage seals, leading to oil leaks.

The waste gases that leave the engine are comprised of about 70% unburned fuel. They used to be vented off the crankcase into the atmosphere. But starting in 1964, laws mandated that these gases be recaptured. Manufacturers began installing PCV systems, which recycled the gases into the air intake system where they could be mixed with fuel and sent to the engine to be burned.

The PCV valve is a one-way valve attached to the crankcase. Waste gases exit the crankcase through the valve but cannot enter.

Over time, the waste gases leave deposits on the PCV valve that can gum it up. So it needs to be replaced occasionally. This is an inexpensive part of preventive maintenance that is often overlooked, but which can have very expensive consequences. It's good auto advice to keep this little valve clean and working well.

In order to maintain efficient circulation, the PCV system also has a breather tube that allows clean air to enter the crankcase. This air is usually filtered through the engine air filter. But some vehicles have a separate air filter for the breather tube called the breather element. If this is the case with your vehicle, proper maintenance of the PCV will include replacing this element. To find out whether your vehicle has this type of PCV system, check your owner's manual or ask your service advisor at Arizona Auto and Radiator Repair.

The PCV system reduces harmful vehicle emissions. The maintenance it requires is simple and inexpensive at Arizona Auto and Radiator Repair. A fouled or damaged PCV system can lead to serious engine damage for Sierra Vista drivers.

Let's all learn to practice good car care. It's good for our wallets, and it's good for our AZ environment.

Arizona Auto and Radiator Repair
1255 E FRY BLVD
Sierra Vista, AZ 85635
520-459-2216
http://www.azautorepair.net

Hold the Oil! (Oil Pan Gasket Replacement)

You've likely heard how important oil is to your vehicle's engine. Did you know that there's one part that's responsible for holding that oil so you can use it every day? It's called the oil pan, and it sits at the bottom of the engine.

The oil pan is a vital, though simple, part of your engine's lubrication system. Oil circulates through parts of your engine to keep them lubricated. It reduces friction so everything works smoothly. Without oil, friction would quickly destroy your engine. The oil pan keeps that oil contained in the lubrication system, so it's important that the oil doesn't leak out. Since it's a metal part attached to another metal part, there is a gasket between the oil pan and the part of the engine it attaches to.

Various things can put stress on the oil pan and gasket, including weather extremes, the speed you're traveling and the condition of the oil. You may drive over a couple of bad roads and kick up debris onto your oil pan. All this wear and tear, heat and time can take their toll. So after a while, the gasket can just wear out and start leaking. It usually starts pretty slowly. If you see oil visible under your vehicle where you park it, that might be a sign of a leaky oil pan gasket. Another sign? You smell burning oil coming from your engine. If the leak is bad and your engine has lost a lot of oil, you may eventually see the oil light go on.

Let your service advisor know if you are experiencing any of these things. Driving with insufficient oil can badly damage your engine. And it can do it quickly. A Arizona Auto and Radiator Repair trained technician will check to find the source of the leak. It may just be a gasket, but it also could be the oil pan is damaged and needs replacing as well.

This is a repair you should get taken care of. Your engine needs its lubrication system intact to provide you many years of service.

Arizona Auto and Radiator Repair
1255 E FRY BLVD
Sierra Vista, AZ 85635
520-459-2216
http://www.azautorepair.net